Pt-TiO2/Graphene催化剂的氧还原和甲醇氧化电催化性能研究

doi:10.13208/j.electrochem.131171

电化学（中英文） ›› 2014, Vol. 20 ›› Issue (4): 377-381. doi: 10.13208/j.electrochem.131171

• 电化学近期研究专辑（厦门大学姜艳霞教授主编） • 上一篇下一篇

Pt-TiO₂/Graphene催化剂的氧还原和甲醇氧化电催化性能研究

戚利^1,2,3，殷瑛^1,2,3，涂文广¹，吴兵兵^1,2,3，王兆生⁵，刘建国^1,2,3,4*，顾军^1,3,4，邹志刚^1,2,3,4

1. 南京大学物理学院环境材料与再生能源研究中心，江苏南京 210093；2. 南京大学现代工程与应用科学学院，江苏南京 210093；3. 江苏省纳米技术重点实验室，江苏南京 210093；4. 南京大学昆山创新研究院，江苏南京 210093；5. 浙江省绍兴县永利新能源研究院有限公司，浙江绍兴 312028

收稿日期:2014-01-17 修回日期:2014-03-10 出版日期:2014-08-28 发布日期:2014-03-20
通讯作者: 刘建国 E-mail:jianguoliu@nju.edu.cn
基金资助:
国家自然科学基金项目（No. 21176111）、浙江省重大科技专项（No. 2012C11014）和绍兴县科技攻关计划项目（No. 2012506）资助

Preparation of Pt-TiO₂/Graphene Composites with High Catalytic Activity towards Methanol Oxidation and Oxygen Reduction Reaction

QI Li ^1,2,3, YIN Ying^1,2,3, TU Wen-guang¹, WU Bing-bing^1,2,3, WANG Zhao-sheng⁵, LIU Jian-guo^1,2,3,4*, GU Jun^1,3,4, ZOU Zhi-gang^1,2,3,4

1. Eco-materials and Renewable Energy Research Center, Nanjing University, Nanjing 210093, China; 2. College of Engineering and Applied sciences, Nanjing University, Nanjing 210093, China; 3. Jiangsu Key Laboratory for Nano Technology, Nanjing University, Nanjing 210093, China; 4. Kunshan Innovation Institute of Nanjing University, Nanjing 210093; 5. Yong Li New Technology Research Institute Company Limited, Shaoxing 312028, Zhejiang, China

Received:2014-01-17 Revised:2014-03-10 Published:2014-08-28 Online:2014-03-20
Contact: LIU Jian-guo E-mail:jianguoliu@nju.edu.cn

摘要/Abstract

摘要： 以二(2-羟基丙酸)二氢氧化二铵合钛（TBA）和氧化石墨烯（GO）为前驱体，通过水热法合成出不同TiO₂含量的TiO₂/Graphene（TiO2/G）复合材料，随之用微波醇热法还原Pt前驱体可得Pt-TiO₂/G催化剂. 实验结果表明，TiO₂可与Pt相互作用，添入适量TiO₂的Pt-TiO₂/G催化剂具有较高的氧还原电催化活性及甲醇氧化的电催化活性与稳定性. 但TiO₂电导率偏低，过量TiO₂的添入反而使其电催化性能降低.

关键词: TiO2, 石墨烯, 氧还原, 甲醇氧化

Abstract: A series of graphene-supported TiO₂ nanoparticles (TiO₂/G) with different TiO₂ contents were prepared by a facile hydrothermal method, and then the Pt-TiO₂/G catalysts were successfully prepared by reducing Pt-precursor with microwave technique. Compared with Pt-G catalysts, the catalytic performance toward oxygen reduction reaction (ORR) and methanol oxidation reaction (MOR) of Pt-TiO₂/G catalysts was improved due to the addition of TiO₂. However, the excessive TiO₂ would lead to a poor catalytic performance of Pt-TiO₂/G catalysts because of the low electrical conductivity of TiO₂.

Key words: TiO₂, graphene, ORR, methanol oxidation

中图分类号:

TM911.4

戚利，殷瑛，涂文广，吴兵兵，王兆生，刘建国*，顾军，邹志刚. Pt-TiO₂/Graphene催化剂的氧还原和甲醇氧化电催化性能研究[J]. 电化学（中英文）, 2014, 20(4): 377-381.

QI Li, YIN Ying, TU Wen-guang, WU Bing-bing, WANG Zhao-sheng, LIU Jian-guo*, GU Jun, ZOU Zhi-gang. Preparation of Pt-TiO₂/Graphene Composites with High Catalytic Activity towards Methanol Oxidation and Oxygen Reduction Reaction[J]. Journal of Electrochemistry, 2014, 20(4): 377-381.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://electrochem.xmu.edu.cn/CN/10.13208/j.electrochem.131171

https://electrochem.xmu.edu.cn/CN/Y2014/V20/I4/377

参考文献

[1] Helmolt R V, Eberle U. Fuel cell vehicles: Status 2007[J]. Journal of Power Sources, 2007, 165(2): 833-843.
[2] Xin Y C, Liu J G, Jie X, et al. Preparation and electrochemical characterization of nitrogen doped graphene by microwave as supporting materials for fuel cell catalysts[J]. Electrochimica Acta, 2012, 60: 354-358.
[3] Liu W M, Xie Y, Liu J G, et al. Experimental study of proton exchange membrane fuel cells using Nafion 212 and Nafion 211 for portable application at ambient pressure and temperature conditions[J]. International Journal of Hydrogen Energy, 2012, 37(5): 4673-4677.
[4] Ye J L, Liu J G, Zou Z G, et al. Preparation of Pt supported on WO3-C with enhanced catalytic activity by microwave-pyrolysis method[J]. Journal of Power Sources, 2010, 195(9): 2633-2637.
[5] Wu B B, Li B, Liu W M, et al. The performance improvement of membrane and electrode assembly in open-cathode proton exchange membrane fuel cell[J]. International Journal of Hydrogen Energy, 2013, 38(25): 10978-10984.
[6] Tiido K, Alexeyeva N, Couillard M, et al. Graphene-TiO2 composite supported Pt electrocatalyst for oxygen reduction reaction[J]. Electrochimica Acta, 2013, 107: 509-517.
[7] Liu X, Chen J, Liu G, et al. Enhanced long-term durability of proton exchange membrane fuel cell cathode by employing Pt/TiO2/C catalysts[J]. Journal of Power Sources, 2010, 195(13): 4098-4103.
[8] Xia B Y, Wu H B, Chen J S, et al. Formation of Pt-TiO2-rGO 3-phase junctions with significantly enhanced electro-activity for methanol oxidation[J]. Physical Chemistry Chemical Physics, 2012, 14(2): 473-476.
[9] Fan Y, Yang Z J, Huang P, et al. Pt/TiO2-C with hetero interfaces as enhanced catalyst for methanol electrooxidation[J]. Electrochimica Acta, 2013, 105: 157-161.
[10] Xin Y C, Liu J G, Zhou Y, et al. Preparation and characterization of Pt supported on graphene with enhanced electrocatalytic activity in fuel cell[J]. Journal of Power Sources, 2011, 196(3): 1012-1018.
[11] Geim A K, Novoselov K S. The rise of graphene[J]. Nature Materials, 2007, 6(3): 183-191.
[12] Tu W G, Zhou Y, Liu Q, et al. An in situ simultaneous reduction-hydrolysis technique for fabrication of TiO2-Graphene 2D sandwich-like hybrid nanosheets: graphene-promoted selectivity of photocatalytic-driven hydrogenation and coupling of CO2 into methane and ethane[J]. Advanced Functional Materials, 2013, 23(14): 1743-1749.
[13] Hummers W S, Offeman R E. Preparation of graphitic oxide[J]. Journal of the American Chemical Society, 1958, 80(6): 1339.
[14] Montero-Ocampo C, Vargas Garcia J, Arce Estrada E. Comparison of TiO2 and TiO2-CNT as cathode catalyst supports for ORR[J]. International Journal of Electrochemical Science, 2013, 8(12):1278-1280.
[15] Shim J, Lee C R, Lee H K, et al. Electrochemical characteristics of Pt-WO3/C and Pt-TiO2/C electrocatalysts in a polymer electrolyte fuel cell[J]. Journal of Power Sources, 2001, 102(1/2): 172-177.
[16] Zhao X, Zhu J B, Liang L, et al. Enhanced activity of Pt nano-crystals supported on a novel TiO2@N-doped C nano-composite for methanol oxidation reaction[J]. Journal of Materials Chemistry, 2012, 22(37): 19718-19725.
[17] Qu Y T, Gao Y Z, Kong F D, et al. Pt-rGO-TiO2 nanocomposite by UV-photoreduction method as promising electrocatalyst for methanol oxidation[J]. International Journal of Hydrogen Energy, 2013, 38(28): 12310-12317.

Pt-TiO₂/Graphene催化剂的氧还原和甲醇氧化电催化性能研究

Preparation of Pt-TiO₂/Graphene Composites with High Catalytic Activity towards Methanol Oxidation and Oxygen Reduction Reaction

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

Metrics

[1]	陈发东, 谢卓洋, 李孟婷, 陈四国, 丁炜, 李莉, 李静, 魏子栋. 系列综述（1/4）:重庆大学魏子栋教授课题组在电化学能源转换方面的研究进展：燃料电池高性能氧还原催化剂[J]. 电化学（中英文）, 2024, 30(7): 2314007-.
[2]	崔苗苗, 韩联欢, 曾兰平, 郭佳瑶, 宋维英, 刘川, 吴元菲, 罗世翊, 刘云华, 詹东平. 单层石墨烯微米尺度图案化和功能化：调控电子传输特性[J]. 电化学（中英文）, 2024, 30(3): 2305251-.
[3]	郑天龙, 欧明玉, 徐松, 毛信表, 王释一, 和庆钢. 一体式可再生燃料电池双功能氧催化剂的研究进展[J]. 电化学（中英文）, 2023, 29(7): 2205301-.
[4]	孟庆成, 金林薄, 马梦泽, 高学庆, 陈爱兵, 周道金, 孙晓明. 层状金属氢氧化物中铁位点辅助分散铂纳米颗粒用于高效甲醇氧化[J]. 电化学（中英文）, 2023, 29(2): 2215007-.
[5]	刘思淼, 周景娇, 季世军, 文钟晟. FeNi-CoP/NC双功能催化剂的制备及电催化性能研究[J]. 电化学（中英文）, 2023, 29(10): 211118-.
[6]	王健, 轩文辉, 何倩, 蒋金霞, 周圆圆, 聂瑶, 廖强, 邵敏华, 丁炜, 魏子栋. 类超晶格结构：有序性传质赋予燃料电池高品质输出性能[J]. 电化学（中英文）, 2023, 29(1): 2215003-.
[7]	郭鸿波, 王亚妮, 郭凯, 雷海涛, 梁作中, 张学鹏, 曹睿. 吸电子和亲水性Co-卟啉促进电催化氧还原反应的研究[J]. 电化学（中英文）, 2022, 28(9): 2214002-.
[8]	张天恩, 颜雅妮, 张俊明, 瞿希铭, 黎燕荣, 姜艳霞. 调控Pt₃Zn合金化程度改善酸性氧还原活性与稳定性[J]. 电化学（中英文）, 2022, 28(4): 2106091-.
[9]	冯雅辰, 王翔, 王宇琪, 严会娟, 王栋. 电催化氧还原反应的原位表征[J]. 电化学（中英文）, 2022, 28(3): 2108531-.
[10]	李萌, 冯立纲. 磷化物助力铂基催化剂甲醇电氧化的研究进展[J]. 电化学（中英文）, 2022, 28(1): 2106211-.
[11]	袁会芳, 张越, 翟兴吾, 胡立兵, 葛桂贤, 王刚, 于锋, 代斌. 氮掺杂碳原位锚定铜纳米颗粒用于高效氧还原反应催化剂[J]. 电化学（中英文）, 2021, 27(6): 671-680.
[12]	唐佳, 张晓明, 于陕升, 王素力, 孙公权. Pt_xCu_y/C电催化剂甲醇氧化反应性能及机理研究[J]. 电化学（中英文）, 2021, 27(5): 508-517.
[13]	刘双娟, 王海静, 郭靖, 王鹏程, 周昊, 孟才, 郭汉杰. 电沉积法制备石墨烯纸-金属复合材料的初步研究[J]. 电化学（中英文）, 2021, 27(4): 396-404.
[14]	林华, 吴艺津, 李君涛, 周尧. 一锅法制备Fe₂O₃@Fe-N-C氧还原电催化剂及其锌-空气电池的性能研究[J]. 电化学（中英文）, 2021, 27(4): 366-376.
[15]	李文杰, 田东旭, 杜红, 燕希强. ORR催化剂Ni_m@Pt₁Au_n_-_m_-1(n = 19, 38, 55, 79; m = 1, 6, 13, 19)的密度泛函研究[J]. 电化学（中英文）, 2021, 27(4): 357-365.