不同碱液单晶硅表面织构的初步研究(英文)

doi:10.61558/2993-074X.1921

电化学（中英文） ›› 2008, Vol. 14 ›› Issue (4): 358-364. doi: 10.61558/2993-074X.1921

不同碱液单晶硅表面织构的初步研究(英文)

豆玉华;周玉琴;朱美芳;宋爽;刘丰珍;刘金龙;张占军;

中国科学院研究生院;北京太阳能研究所;

收稿日期:2008-11-28 修回日期:2008-11-28 出版日期:2008-11-28 发布日期:2008-11-28

Study on the Texturization of c-Si Wafers by Different Kinds of Alkaline for Heterojunction Solar Cells

DOU Yu-hua1,ZHOU Yu-qin1*,ZHU Mei-fang1,SONG Shuang2,LIU Feng-zhen1,LIU Jin-long1,ZHANG Zhan-jun1*

(1.Graduate University of the Chinese Academy of Sciences,Beijing 100049,China;2.Beijing Solar Energy Institute,Beijing 100083,China

Received:2008-11-28 Revised:2008-11-28 Published:2008-11-28 Online:2008-11-28

摘要/Abstract

摘要： 分别以氢氧化钠(NaOH)、碳酸钠(Na2CO3)和磷酸钠(Na3PO4.12H2O)作为刻蚀剂,研究刻蚀浓度、温度(θ)、刻蚀时间(te)和添加剂(异丙醇(IPA)、碳酸氢钠(NaHCO3))对晶体硅表面织构化的影响,用场发射扫描电子显微镜表征织构效果.通过优化工艺,可得到较低的平均表面反射率(Rav),按使用的刻蚀剂分别为:9.70%(NaOH)、9.76%(Na2CO3)和8.63%(Na3PO4.12H2O).据此分析了Rav和织构表面形貌之间的关系.发现添加剂IPA在Na3PO4.12H2O或Na2CO3与NaOH 3种刻蚀剂溶液中均可明显起改善织构效果.NaHCO3在某些方面具有与IPA的相同作用,同时又能促进大金字塔的形成.文中同时初步提出有关刻蚀过程的机理.

关键词: 单晶硅, 织构, 碱液, 反射率, 表面形貌

Abstract: The texturization of(100) crystalline silicon(c-Si) wafer was studied by field-emission scanning electron microscope using different kinds of etchant: sodium hydroxide,sodium carbonate and tribasic sodium phosphate.By optimizing the etching parameters,the lowest values of averaged reflectance(Rav) were obtained to be 9.70% for NaOH,9.76% for Na2CO3 and 8.63% for Na3PO4·12H2O,which is comparable to that of the wafer with textured surface covered with an anti-reflection coating of either silicon nitride or thermally grown silicon dioxide.The relation of Rav and surface morphology of textured wafer was analyzed.Moreover,special emphasis was put on the role of isopropyl alcohol(IPA) and sodium bicarbonate for texturization.It is proved that IPA decreased the etching rate but improved the morphology of the textured surface.It seems that played NaHCO3 played the similar role of IPA but resulted in the formation of large pyramid.The mechanism of texturization by different kinds of etchant was suggested.

Key words: crystalline silicon, texturization, alkaline, reflectance, surface morphology

中图分类号:

TM914.41

豆玉华, 周玉琴, 朱美芳, 宋爽, 刘丰珍, 刘金龙, 张占军, . 不同碱液单晶硅表面织构的初步研究(英文)[J]. 电化学（中英文）, 2008, 14(4): 358-364.

DOU Yu-hua, ZHOU Yu-qin, ZHU Mei-fang, SONG Shuang, LIU Feng-zhen, LIU Jin-long, ZHANG Zhan-jun. Study on the Texturization of c-Si Wafers by Different Kinds of Alkaline for Heterojunction Solar Cells[J]. Journal of Electrochemistry, 2008, 14(4): 358-364.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://electrochem.xmu.edu.cn/CN/10.61558/2993-074X.1921

https://electrochem.xmu.edu.cn/CN/Y2008/V14/I4/358

参考文献

[1]Nishimoto Y,Namba K.Investigation of texturizationfor crystalline silicon solar cells with sodium carbonatesolutions[J].Solar Energy Material&Solar Cells,2000,61:393-402. [2]Sparber W,Schultz O,Biro D,et al.Comparison oftexturing methods for crystalline silicon solar cells usingKOHand Na2CO3.In:3rd World Conference on Pho-tovoltaic Energy Conversion[C].Osaka,2003.1372-1375. [3]Marrero N,Gonz lez-D az B,Guerrero-Lemus R,et al.Optimization of sodium carbonate texturization on large-area crystalline silicon solar cells[J].Solar EnergyMaterials&Solar Cells,2007,(91):1943-1947. [4]Vallejo B,Gonzalez-Man s M,Martnez-Lopez J,et al.On the texturization of monocrystalline silicon with sodi-um carbonate solutions[J].Solar Energy,2007,(81):565-569. [5]Xi Zhenqiang,Yang Deren,Que Duanlin.Texturizationof monocrystalline silicon with tribasic sodium phos-phate[J].Solar Energy Mater Solar Cells,2003,77:255-263. [6]Gangopadhyay U,Kim K H,Dhungel S K,et al.Ano-vel lowcost texturization method for large area commer-cial mono-crystalline silicon solar cells[J].Solar Ener-gy Materials&Solar Cells,2006,90:3557-3567. [7]Irena Zubel,Malgorzata Kramkowska.The effect of iso-propyl alchohol on etching rate and roughness of(100)Si surface etched in KOH and TMAH solution[J].Sensors and Actuators A,2001,93:138-174. [8]Declercq MJ,Gerzberg L,Meindl J D.Optimization ofthe hydrazine-water for anisotropic etching of silicon inintegrated circuit technology[J].J Electrochem Soc,1975,122(4):545-552. [9]Restrepo F,Backus C E.On black solar cells or thetetrahedral texturing of silicon surface[J].IEEE TransElectron Dev,1976,ED-23(10):1195-1197. [10]Seidel H,Csepregi L,Heuberger A,et al.Anisotrop-ic etching of crystalline silicon in alkaline solutionⅠ:Orientation dependence and behavior of passivation lay-ers[J].J Electrochem Soc,1990,137(11):3612.

不同碱液单晶硅表面织构的初步研究(英文)

Study on the Texturization of c-Si Wafers by Different Kinds of Alkaline for Heterojunction Solar Cells

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 9

Metrics

[1]	刘仁志, 谢平令, 王翀. 电沉积铜箔的微观组织结构——三维电结晶模式中的电结晶机理探讨[J]. 电化学（中英文）, 2022, 28(6): 2104481-.
[2]	蒋利民*，邓文波，应俊龙. 铝合金电解加工中的钝化行为及其对加工过程的影响[J]. 电化学（中英文）, 2014, 20(1): 28-32.
[3]	申丹丹, 杨防祖, 吴辉煌, . 2,2′-联吡啶和亚铁氰化钾对乙醛酸化学镀铜的影响[J]. 电化学（中英文）, 2007, 13(1): 67-71.
[4]	程璇, 刘峰名, 温作新, 林昌健, 田中群, 薛茹. 两步法制备多孔硅及其表征II :脉冲电流法(英文)[J]. 电化学（中英文）, 2001, 7(1): 78-84.
[5]	程璇,刘峰名,林昌健,温作新,田中群,薛茹. 两步法制备多孔硅及其表征I:恒电流法(英文)[J]. 电化学（中英文）, 2000, 6(4): 399-405.
[6]	黄令,许书楷,汤皎宁,杨防祖,周绍民. Ni-Mo合金电沉积层织构及形成机理[J]. 电化学（中英文）, 1997, 3(2): 174-178.
[7]	韩克平，方景礼. 紫铜化学抛光的电化学研究[J]. 电化学（中英文）, 1996, 2(3): 310-313.
[8]	姚立广，王明贤. 析氯钛基RuO_2－Co_3O_4－TiO_2（60）涂层的研究[J]. 电化学（中英文）, 1996, 2(3): 293-293.
[9]	许书楷，杨防祖，周绍民. 电沉积条件对锌镀层织构的影响[J]. 电化学（中英文）, 1995, 1(4): 408-414.