柠檬酸中锌防蚀剂（1,3-Dioxolan-2-ylmethyl）三苯基溴化磷和碘离子的协同效应研究

doi:10.13208/j.electrochem.151222

电化学（中英文） ›› 2017, Vol. 23 ›› Issue (4): 441-455. doi: 10.13208/j.electrochem.151222

柠檬酸中锌防蚀剂（1,3-Dioxolan-2-ylmethyl）三苯基溴化磷和碘离子的协同效应研究

M. Saadawy

埃及亚历山大大学理学院化学系，亚历山大 21321

收稿日期:2015-12-22 修回日期:2016-03-10 发布日期:2016-04-14 出版日期:2017-08-25
通讯作者: M. Saadawy E-mail:marwan.saadawy@yahoo.com
基金资助:
The author wishes to thank Prof. Dr. Beshir Ahmed Abd El-Nabey, Prof. Dr. Essam Khamis and Prof. Dr. Ashraf Moustafa, Department of chemistry, Faculty of Science, Alexandria University, Alexandria, Egypt for continuous support and providing advanced instruments.

An investigation of the synergistic effect between (1,3-Dioxolan-2-ylmethyl)–triphenylphosphonium bromide and iodide ion for the corrosion inhibition of zinc in citric acid

M. Saadawy

Chemistry Department, Faculty of Science, Alexandria University, Egypt Ibrahimia, El-Horeya Street P.O. BOX 426 Alexandria 21321

Received:2015-12-22 Revised:2016-03-10 Online:2016-04-14 Published:2017-08-25
Contact: M. Saadawy E-mail:marwan.saadawy@yahoo.com
Supported by:
The author wishes to thank Prof. Dr. Beshir Ahmed Abd El-Nabey, Prof. Dr. Essam Khamis and Prof. Dr. Ashraf Moustafa, Department of chemistry, Faculty of Science, Alexandria University, Alexandria, Egypt for continuous support and providing advanced instruments.

摘要/Abstract

摘要： 采用称重法、动电位极化法和电化学交流阻抗技术研究了30 ^oC时(1,3-Dioxolan-2-ylmethyl)三苯基溴化磷（DTPB）对0.5 mol·L^-1柠檬酸中锌腐蚀行为的影响. 通过在环保型电解槽中对锌进行酸洗，这在文献中是不常用的. 结果表明，DTPB作为一种有效的防蚀剂，添加浓度仅为3×10^-3 mol·L^-1时，锌在柠檬酸溶液中的防蚀效率可达98.9%. 由于DTPB和碘化钾存在协同效应，两者联用时的防蚀效果要比单独使用DTPB强，防蚀参数为1.2，并随温度升高而减小. 本文提出了碘化钾作为吸附媒介，可使金属表面与DTPB结合的防蚀机制.

关键词: zinc, polarization, EIS, acid corrosion, synergism

Abstract: The effect of (1,3-Dioxolan-2-ylmethyl)-triphenylphosphonium bromide (DTPB) on the zinc corrosion in 0.5 mol·L^-1 citric acid solution was investigated at 30 ^oC using weight loss, potentiodynamic polarization and electrochemical impedance spectroscopy (EIS) techniques. An ecofriendly bath was used for acid cleaning of zinc, which has not been widely used in literatures. The results showed that DTPB could serve as an effective inhibitor for the zinc corrosion in a citric acid solution with the inhibition efficiency of 98.9% at the DTPB concentration of 3×10^-3 mol·L^-1. A synergistic effect between DTPB and potassium iodide (KI) enhanced the inhibition capability of DTPB, and better inhibition efficiency was achieved as compared with that by using DTPB alone. The synergism parameter had a value of 1.2 and was found to decrease with temperature. An inhibition mechanism is proposed by which KI acts as an adsorption mediator for bonding metal surface and DTPB.

Key words: zinc, polarization, EIS, acid corrosion, synergism

中图分类号:

O646

M. Saadawy. 柠檬酸中锌防蚀剂（1,3-Dioxolan-2-ylmethyl）三苯基溴化磷和碘离子的协同效应研究[J]. 电化学（中英文）, 2017, 23(4): 441-455.

M. Saadawy. An investigation of the synergistic effect between (1,3-Dioxolan-2-ylmethyl)–triphenylphosphonium bromide and iodide ion for the corrosion inhibition of zinc in citric acid[J]. Journal of Electrochemistry, 2017, 23(4): 441-455.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://electrochem.xmu.edu.cn/CN/10.13208/j.electrochem.151222

https://electrochem.xmu.edu.cn/CN/Y2017/V23/I4/441

[1]	李玉楠, 王佳, 张伟, . 有机涂层在浸泡和干湿循环条件下劣化过程的EIS对比研究[J]. 电化学（中英文）, 2010, 16(4): 393-400.
[2]	何少平, 熊金平, 唐聿明, 左禹, . 无机富锌/环氧云铁/脂肪族聚氨酯复合涂层失效过程阻抗与吸水性变化的EIS研究[J]. 电化学（中英文）, 2010, 16(4): 362-367.
[3]	刘福国, 杜敏, 王庆璋, . 新型缓蚀剂对钻具在31% NaCl溶液中电化学行为研究[J]. 电化学（中英文）, 2007, 13(4): 382-386.
[4]	向斌, 陈文, 黄文章, 邢少华, 张胜涛, . 电化学方法研究氯气冷凝器的腐蚀[J]. 电化学（中英文）, 2007, 13(4): 411-414.
[5]	樊小勇, 许金梅, 庄全超, 江宏宏, 黄令, 姜艳霞, 董全峰, 孙世刚, . 锂离子电池Sn-SBA15负极材料的复合电镀制备及其性能[J]. 电化学（中英文）, 2007, 13(1): 25-29.
[6]	郑奕, 王建明, 陈华, 邵海波, 张鉴清. 钡添加剂对二次碱性锌电极性能的影响[J]. 电化学（中英文）, 2004, 10(3): 314-319.
[7]	黄波, 李飞, 俞晴春, 陈刚, 胡克鳌. 熔融碳酸盐燃料电池ZnO/NiO阴极稳定性及电化学性能研究[J]. 电化学（中英文）, 2004, 10(2): 181-189.
[8]	罗俊雄, 饶正, 陈桂清. 海生物附著对钢板管椿腐蚀之影响[J]. 电化学（中英文）, 2003, 9(3): 259-264.
[9]	赵永韬, 吴建华, 钱建华, 于辉. 阴极保护和缓蚀剂技术联合保护成膜的阻抗谱研究[J]. 电化学（中英文）, 2000, 6(1): 89-94.

柠檬酸中锌防蚀剂（1,3-Dioxolan-2-ylmethyl）三苯基溴化磷和碘离子的协同效应研究

An investigation of the synergistic effect between (1,3-Dioxolan-2-ylmethyl)–triphenylphosphonium bromide and iodide ion for the corrosion inhibition of zinc in citric acid

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 9

Metrics